We have converted almost all types of units we sell and have knowledge in the boring and installation of the units. Machines that require hole boring will come with boring templates and bolt hole centering dowels. The customer is responsible for any necessary block off plates and small wire to connect the alternator output to the amp gauge and amp gauge to the positive battery cable connection as well as small wire to connect the starter button to the solenoid.Īll units come with complete instructions. Our complete kits include the following parts: 24 volt starter, 24 volt alternator (belt drive or gear drive as required per application), Amp gauge, starter button, 1/0 welding cable in bulk, solder or crimp on bronze cable ends and copper eyes. They are the perfect solution to your pony motor problems. We have developed special drive end housings for our starters and gear drive alternators that make it possible, in most cases, to simply “bolt up” your conversion starter to the tractor. To go with that, you need a 24 V voltage regulator. We offer a 12 volt conversion alternator for the same price, 12 volts, 189 Amps 12. Much smaller, and more reliable package 11. The rotor in a 24 Volt alternator will be wound differently than a 12 V rotor and therefore needs to be done properly. No More Searching For Hard To Find Alternators, or Parts 10. Note the three screws that hold the brush holder assembly and voltage regulator, all three are insulated. Since that time hundreds of kits, starters, and parts have been sold around the world including Canada, England, Australia, and New Zealand. I was a rebuilder so the information I am going to give you is from first hand experience, no guessing. For the 6, 12 or 24 volt positive ground application you must wire the alternator like the one shown above. Auto-Lec Rebuilders has been building Caterpillar Direct Start Conversion Kits since 1980. Standard Resistive Gauges 52mm 12/24 Volt (2011) Standard Resistive Gauges 52mm 12/24 Volt Retrofit Kit (Temperature, Pressure, Level, Trim) (2013).
0 Comments
Leave a Reply. |
AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |